Knowledge and understanding of what occurs during the fermentation process is critical to implementing sound management practices when harvesting, storing and feeding ensiled forages.
If managed well, then fermentation makes the silage easier to digest in the rumen and the silage nutrients easier to assimilate (uptake) by the animal.
In effect, a good fermentation performs much of the work of digestion prior to consumption by the ruminant.
Good silage management practices can help prevent or at least minimise losses in forage dry matter (DM).
Often times these losses in dry matter go undetected unless the amount of forage ensiled and feed being removed from the storage structure, is measured accurately.
Most farms do not complete and summarise these measurements. Unlike a hetero-lactic fermentation.
Silo-King is formulated with three exclusive, EU-approved, homo-lactic bacteria which do not produce any greenhouse gases (GHG) during their fermentation. This quality is critical and allows for both maximal dry matter and energy retention of the fermenting feed.
Also, homo-lactic fermented silages are known to be very palatable to dairy cattle.
Phases of fermentation
Phase 1 starts at crop harvest and under ideal conditions of moisture, chop length, and firm (high density) packing, lasts only a few hours. This first phase continues until either the oxygen or water soluble carbohydrate supply has been depleted.
In poorly sealed and/or packed silos, the clamp life of the resulting forage can be reduced since the initial growth of yeasts and bacillus species occur during this phase.
Once feedout occurs, yeasts can rapidly increase in numbers causing heating in the feed clamp and lowering feed consumption.
Phase 2 begins when the trapped oxygen supply is depleted and generally lasts no longer than 24 to 96 hours. During this phase, anaerobic (without oxygen) hetero-fermentation occurs. The dominating bacteria during this phase is enterobacteria (e.g. E.coli).
These hetero-fermenters produce both acetic and lactic acid, but tend to be inefficient at producing these acids resulting in nutrient and dry matter losses of the fermenting crop. The final ratios of these acids depend on the crop maturity, moisture, fermentable sugars and bacterial populations.
The reason Silo-King is also formulated with food-grade antioxidants and anti-fungals is to shorten Phases 1 and 2, resulting in greater DM and nutrient retention of the harvested crop. When the pH drops below five, Phase 3 of silage fermentation begins.
Critical middle phase
Phase 3 is a critical phase. During this phase, either the homo-lactic or hetero-lactic bacteria will dominate. Homo-lactic bacteria is more efficient than the hetero-lactics, and can rapidly drop the pH of the fermenting forage by efficiently producing lactic acid as the only end product.
Again, this is why Silo-King ‘seeds’ the fresh silage with only homo-lactic bacterial strains. In this phase the stabilisation of temperature of the fermented crop occurs; the dominating bacteria convert water-soluble carbohydrates to acid, which reduces the pH and, in turn, preserves the silage.
Maize silage, in contrast to grasses and legumes, has a lower buffering capacity, more water-soluble carbohydrates, and generally reaches a pH less than or equal to 4.0. When the terminal pH is reached, the forage is ‘preserved’ within the silo.
Silage pH does not indicate the rate or quality of the resulting silage. To determine the quality of the silage, a complete analysis is needed where the feed’s nutritive content including rumen digestibility of the forage’s fibre and dry matter are quantified as well as acetic, lactic analysed.
Reduce fermentation time
Phases 2 and 3 are completed within three days to three weeks from time of harvest. The general recommendation is to wait at least three weeks before feeding newly harvested forages.
The length of this fermentation process will vary depending on the crop harvested (related to buffering capacity), moisture, and maturity of the ensiled crop. Properly applied, a high-quality silage additive, like Silo-King, will decrease fermentation time required.
Silo-King treatment of the forage helps to push fermentation completion towards that best-case scenario of three days. Typically, the sooner the fermentation reaches completion, then the greater the retention of DM and nutrients.
The final temperature of well-preserved silage is less than 25°C (depending on ambient temperatures at harvest and at feedout).
During Phase 4, the EU-approved Silo-King enzymes hydrolyse the forage’s fibres and complex starches.
This results in enhanced nutrient digestion in the rumen of the cow. Also, if needed, the enzyme-released sugars from the fibres and starches can be fermented by the Silo-King homo-lactic bacteria to create lactic acid which efficiently reduces the pH of the silage.
Final phase at feedout
Phase 5: This phase occurs during feedout and is just as important and is often a neglected part of the fermentation process, and can result in substantial dry matter losses as oxygen is reintroduced into the fermented crop.
Proper management of the silage face minimises dry matter losses and optimises feed intakes by dairy and beef stock. Silo-King helps address the issues that can occur in Phase 5, by addressing them all the way back during Phase 1. Controlling yeast and their respiration during Phase 1 – it can pay dividends with regard to longer clamp life during feedout.
Silo-King is formulated with EU-approved silage enzymes and homo-lactic bacteria, antioxidants and anti-fungals with the animal’s nutritional efficiency and the environment in mind.
If you would like more details about Silo-King click here
Find your local Agri-King area manager in the list below:
- Matt Tungate: 07554-401457 – Donegal and Derry;
- John Steen: 07795-673003 – Antrim;
- Robert Kinnear: 07881-315059 – Fermanagh and Tyrone;
- Alan Lockhart: 07813-857618 – Armagh and Down;
- Séamus Brady: 086-0432700 – Cavan and Monaghan;
- Claire Costello: 087-7663921 – Galway, Mayo, Sligo;
- Nicholas Leen: 087-9228000 – Kerry and Clare;
- Michael O’Neill: 087-2436612 – Limerick, south Tipperary and west Cork;
- Amy Lynott: 087-4174287 – east Cork and Waterford;
- Stephen Hughes: 086-7013463 – Wexford and Wicklow;
- Gerard Dunne: 086-8529955 – Kilkenny, Carlow and north Tipperary;
- Kevin McWey: 086-7916250 – Laois, Offaly and Kildare;
- Alan Walker: 087-9877742 – Roscommon, Westmeath, Meath, and Louth;
- Terry Sloane: 087-8106184 – all other areas.
Additional information is available by e-mailing: [email protected]; or alternatively: [email protected].
In addition, you can also visit the Agri-King website at: www.agriking.com.